I, TERENCE LINDSAY FARQUHARSON, Acting Director of Aviation Safety, on behalf of CASA, make this instrument under regulation 66.015 of the Civil Aviation Safety Regulations 1998.

[Signed T. Farquharson]

Terry Farquharson
Acting Director of Aviation Safety

11 July 2013

Part 66 Manual of Standards Amendment Instrument 2013 (No. 1)

1 Name of instrument

 This instrument is the Part 66 Manual of Standards Amendment Instrument 2013 (No. 1).

2 Commencement

 This instrument commences on the day after registration.

3 Amendment of Part 66 Manual of Standards

 The Part 66 Manual of Standards (the MOS) is amended as set out in Schedule 1.

4 Interpretation

  A reference in Schedule 1 to Appendix IV, followed by a reference to a unit of competency, is a reference to the row in Appendix IV that refers to that unit in the first column (Competency units required).

  Example: Appendix IV (MEA211C).

5 Transitional

 (1) If an applicant to whom paragraph 66.A.25 (a) or 66.A.30 (b) of the MOS refers was entitled to the issue of a unit of competency (the unit) immediately before the commencement day, and the unit is replaced on the commencement day by a subsequent version of that unit of competency, the applicant is entitled to the new unit of competency.

 (2) In subsection (1):

commencement day means the day on which this instrument comes into effect.

Schedule 1 Amendments

[1] Section 66.5, Definitions, after paragraph 66.5 (b)

insert

 (c) Unless the contrary intention appears, the term carry out maintenance includes, within its normal meaning, both the supervision of maintenance and carrying out the physical tasks of maintenance.

[2] Sub-sub-subparagraph 66.A.20 (a) 4 (ii) (C)

substitute

 (c) category A licence tasks of a kind mentioned in Appendix II of the Part 145 MOS for the aircraft type rating or ratings held

[3] Sub-sub-subparagraph 66.A.20 (a) 6 (ii) (C)

omit

as line maintenance

insert

as a category A licence task

[4] Section 66.A.20

omit

paragraphs (b) and (c)

[5] Section 66.A.20, Table 1 in the section titled Structures — General (ATA51), after the Note following paragraphs (a) and (b) in column 3 under Conditions or limitations

add

[6] After section 66.A.20 (including Table 1)

insert

66.A.23 Requalification requirements

 (a) For paragraph 66.120 (2) (c) of CASR 1998, the requalification requirements for an A, B1 or B2 aircraft engineer licence holder are:

1. carrying out maintenance of the kind that would be covered by the privileges of any of the licences held, for no less than a total of 100 days; or

2. the holder obtains a report from a Part 147 organisation (an MTO) authorised for category training which states:

 (i) that the holder has been assessed within 28 days of the date of the report; and

 (ii) how the assessment was conducted; and

 (iii) that the MTO has certified that the holder continues to have the knowledge and skills necessary for the holder of an aircraft engineer licence with the ratings on the licence; and

3. in relation to subparagraphs (a) 1 and 2, the holder retains either evidence of carrying out the maintenance, or the report from the MTO, as applicable; and

4. for the purposes of subparagraph (a) 2, the assessment by the MTO must include theory examination and practical assessment in a sampling of the range of maintenance activities that the holder is authorised by their licence to carry out. The report must describe how the assessment by the MTO was performed.

 (b) For paragraph 66.120 (2) (c) of CASR 1998, the requalification requirement for a Category C licence holder is that the Part 145 organisation (an AMO) provides the holder with suitable continuing airworthiness experience to ensure that the holder has re-established their knowledge and skill.

[7] Paragraph 66.A.25 (h)

substitute

 (h) The qualification (comprised of knowledge, competence and assessments) must have been gained within 5 years of making an application for an aircraft maintenance licence or the addition of a category or subcategory to an aircraft maintenance licence.

[8] Heading to section 66.A.30

substitute

Basic practical experience requirements

[9] Paragraph 66.A.30 (e)

omit

(a)

insert

1.

[10] Paragraph 66.A.30 (e)

omit

(b)

insert

2.

[11] Subparagraph 66.A.45 (d) 2

substitute

2. practical training and assessment as specified in sections 66.A.50 and 66.A.55.

[12] Subparagraph 66.A.45 (d) 3

omit

[13] Paragraph 66.A.45 (h)

omit

(i)

insert

1.

[14] Paragraph 66.A.45 (h)

omit

(ii)

insert

2.

[15] Paragraph 66.A.45 (h)

omit

(iii)

insert

3.

[16] After subparagraph 66.A.45 (h) 3

insert

Note   A COA holder, in accordance with CAO 104.0, may also provide type training and assessment for the addition of aircraft type ratings or the removal of exclusions from a Part 66 LAME licence.

[17] Heading to section 66.A.50

substitute

Aircraft type practical training

[18] After paragraph 66.A.50 (b)

insert

 (ba) The practical element of type training may be conducted simultaneously with the conduct of the theoretical element or provided separately as a stand-alone element.

 (bb) Options for practical training include:

1. PCT; or

2. practical on course (POC) training; or

3. structured OJT performed according to a type-specific program.

[19] Heading to section 66.A.55

substitute

On the Job aircraft type Training

[20] Paragraph 66.A.55 (a)

substitute

 (a) In the case of a first type rating to be gained, PCT or POC alone is not acceptable for type rating endorsement. In addition to PCT or POC, an applicant must also complete on the job training (OJT).

 (aa) In the case of a rating in another licence category or subcategory to be obtained after the type rating referred to in paragraph (a):

1. if using POC training, POC training must be supplemented by OJT; and

2. if using PCT training, no supplementation by OJT is required.

[21] Paragraph 66.A.55 (c)

after

conducted

insert

and managed

[22] After paragraph 66.A.55 (c)

insert

 (ca) For paragraph (c), the maintenance organisation approved by CASA must be:

1. an approved maintenance organisation (AMO) issued with an approval under regulation 145.030 of CASR 1998 to carry out maintenance activities; or
2. an organisation holding a certificate of approval to carry out maintenance activities issued under regulation 30 of the Civil Aviation Regulations 1988.

[23] After paragraph 66.A.70 (d)

insert

 (e) Units of competency are required as mentioned in Appendix VIII before the removal of an exclusion from a category or subcategory of licence in accordance with paragraph (b).

[24] Appendix I, Part 3, Module 13, item 13.14, Hydraulic power (ATA29), Filters, from column B2

omit

3

insert

1

[25] Appendix III, Part 2, item 5, ATA chapter 08, in columns B1.1, B1.2, B1.3 and B1.4

omit

3

insert

1

[26] Appendix III, Part 2, item 5, ATA chapter 65A, in column 2

after

Tail rotor drive

insert

monitoring and indicating

[27] Appendix III, Part 2, item 5, ATA chapter 25A, in column 2 in the section titled Aircraft systems

after

Electronic

insert

equipment including

[28] Appendix III, Part 2, item 5, ATA chapter 29 (second reference), in column 1 in the section titled Aircraft systems

omit

29

insert

29A

[29] Appendix III, Part 2, item 5, ATA chapter 32 (second reference), in column 1 in the section titled Aircraft systems

omit

32

insert

32A

[30] Appendix III, Part 2, item 5, ATA chapter 36 (second reference), in column 1 in the section titled Aircraft systems

omit

36

insert

36A

[31] Appendix III, Part 2, item 5, ATA chapter 73, in column 2 in the section titled Turbine engines

omit

controls

insert

control

[32] Appendix III, Part 2, item 5, ATA chapter 73-20, in column 1 in the section titled Turbine engines

omit

73-20

insert

73A

[33] Appendix III, Part 2, item 5, ATA chapter 70A, in column 2 in the section titled Piston engines

after

operation,

substitute

(carburettors, fuel injection systems, induction, exhaust and cooling systems, supercharging/turbocharging, lubrication systems)

[34] Appendix III, Part 2, item 5, ATA chapter 76, in column 2 in the section titled Piston engines

omit

controls

insert

control

[35] Appendix III, Part 2, item 5, ATA chapter 60, in column 1 in the section titled Aeroplane propellers

omit

60

insert

60A

[36] Appendix III, Part 2, item 5, ATA chapter 60F, in column 1 in the section titled Aeroplane propellers

omit

60F

insert

61F

[37] Appendix III, Part 3

omit

items 2 and 3

[38] Appendix III, Part 3, items 4 and 5

renumber as 2 and 3 respectively

[39] Appendix III, Part 4, Section B, item 1

before

MTO’s

insert

AMO’s or

[40] Appendix IV, column 1

omit

MEA105B

insert

MEA105C

[41] Appendix IV, column 1

omit

MEA111B

insert

MEA111C

[42] Appendix IV, column 1

omit

MEA119A

insert

MEA119B

[43] Appendix IV, column 1

omit

MEA142A

insert

MEA142B

[44] Appendix IV, (MEA211C), after X, in columns B1.1 to B1.4

insert

or MEA223D and 227D

[45] Appendix IV, column 1

omit

MEA223C

insert

MEA223D

[46] Appendix IV (MEA223D), in columns B1.1, B1.2, B1.3 and B1.4

insert

X or MEA211C

[47] Appendix IV, column 1

omit

MEA224B

insert

MEA224C

[48] Appendix IV, column 1

omit

MEA225B

insert

MEA225C

[49] Appendix IV, column 1

omit

MEA226C

insert

MEA226D

[50] Appendix IV, column 1

omit

MEA227C

insert

MEA227D

[51] Appendix IV (MEA227D), in columns B1.1, B1.2, B1.3 and B1.4

insert

X or MEA211C

[52] Appendix IV, column 1

omit

MEA228C

insert

MEA228D

[53] Appendix IV, column 1

omit

MEA229C

insert

MEA229D

[54] Appendix IV, column 1

omit

MEA230B

insert

MEA230C

[55] Appendix IV (MEA230C), in column B2

omit

MEA231B

insert

MEA231C

[56] Appendix IV, column 1

omit

MEA231B

insert

MEA231C

[57] Appendix IV (MEA231C), in column B2

omit

MEA230B

insert

MEA230C

[58] Appendix IV, column 1

omit

MEA232B

insert

MEA232C

[59] Appendix IV, column 1

omit

MEA241B

insert

MEA241C

[60] Appendix IV, column 1

omit

MEA303C

insert

MEA303D

[61] Appendix IV (MEA304C), in columns B1.3 and B1.4

omit

MEA317B

insert

MEA317C

[62] Appendix IV, column 1

omit

MEA318B

insert

MEA318C

[63] Appendix IV, column 1

omit

MEA319B

insert

MEA319C

[64] Appendix IV, column 1

omit

MEA320B

insert

MEA320C

[65] Appendix IV, column 1

omit

MEA321B

insert

MEA321C

[66] Appendix IV, column 1

omit

MEA322B

insert

MEA322C

[67] Appendix IV, column 1

omit

MEA328B

insert

MEA328C

[68] Appendix IV, column 1

omit

MEA339A

insert

MEA339C

[69] Appendix IV, new units of competency, after the row that refers to MEA348A in the first column

insert

[70] Appendix IV (MEA365A), in column A4

omit

X

[71] Appendix IV (MEA365A), in column B1.4

insert

X

[72] Appendix IV (MEA408B and MEA409B)

omit

[73] Appendix IV (MSAENV272B)

omit

insert

[74] Appendix IV (MSAENV272B), in columns B1.1, B1.2, B1.3, B1.4 and B2

omit

X

[75] Appendix IV

add at the end

[76] After Appendix VII

insert

Appendix VIII

Units of competency required for removal of an exclusion from a category or subcategory of licence